A Study on the Preparation and Stability of Emulsified Acid for Carbonate Matrix Acidizing

Chayoung Song and Jeonghwan Lee

doi:10.32390/ksmer.2021.58.6.568

All Issue

2021 Vol.58, Issue 6 Preview Page Next Page

Research Paper

A Study on the Preparation and Stability of Emulsified Acid for Carbonate Matrix Acidizing 탄산염암의 암체 산처리 공법을 위한 유화산 제조 및 안정성 평가에 관한 연구

31 December 2021. pp. 568-579

PDF XML

Abstract

본 연구에서는 탄산염암의 암체 산처리 공법을 위해 유화산을 제조하고 안정성 평가 연구를 수행하였다. 상온과 고온에서 안정성을 확보한 W/O (water-in-oil) 에멀젼(emulsion)을 제조하기 위해 양이온성 유화제와 비이온성 유화제를 친수성-친유성 균형(hydrophile-lipophile balance, HLB) 기준으로 혼합하여 사용하였고, 안정성을 평가하기 위해 액적 시험(droplet test)과 상분리 시험(separation test)을 수행하였다. 유화산 제조 결과, 상온과 고온(90°C)에서 상분리가 일어나지 않는 유체 안정성을 가진 W/O 에멀젼을 확보하였으며, 이때 양이온성 유화제와 비이온성 유화제를 단독으로 사용하는 것 보다 두 유화제를 혼합하여 사용하였을 때 안정성 측면에서 우수함을 확인하였다. 실험을 통해 도출한 결과는 향후 탄산염암 저류층 현장에서 유화산 제조 가이드라인을 제공할 수 있을 것으로 기대된다.

키워드

탄산염암 저류층

암체 산처리 공법

유화산

혼합 유화제

안정성 평가

This study presents the preparation and stability of emulsified acid for carbonate matrix acidizing. Cationic and nonionic emulsifiers were mixed using hydrophile-lipophile balance (HLB) values to prepare water-in-oil emulsion stable at room temperature and high temperature, and droplet and separation tests were carried out to evaluate the fluid stability. As the result, W/O emulsion with fluid stability that did not cause phase separation at room and the high temperature (90°C) was ensured. Furthermore, it was confirmed that the use of two emulsifiers resulted in superior outcomes compared to using cationic emulsifiers or nonionic emulsifiers individually. Therefore, the proposed results can be utilized as guidelines for the preparation of emulsified acids in carbonate reservoirs.

Keywords

Carbonate reservoirs

Matrix acidizing

Emulsified acid

Mixed emulsifier

Stability test

References

Alabdulmohsen, A., 2015. Experimental study of crude oil emulsion stability by surfactants and nanoparticles, MS Thesis, Missouri University of Science and Technology, USA, p.9-18.

Al-Mutairi, S.H., Hill, A.D., and Nasr-El-Din, H.A., 2007. Effect of droplet size, emulsifier concentration, and acid volume fraction on the rheological properties and stability of emulsified acids, Proc. of the SPE European Formation Damage Conference, SPE, Scheveningen, The Netherlands, p.1-16. 10.2118/107741-MS

Cairns, A.J., Al-Muntasheri, G.A., Sayed, M., Fu, L., and Giannelis, E.P., 2016. Targeting enhanced production through deep carbonate stimulation: Stabilized acid emulsions, Proc. of the SPE International Conference and Exhibition on Formation Damage Control, SPE, Lafayette, Louisiana, USA, p.1-24. 10.2118/178967-MS

Hong, I., Kim, S., Park, B., Choi, J., and Lee, S., 2016. Evaluation of emulsion stability for cosmetic facial cream emulsion using mixed nonionic emulsifier, Journal of the Korean Society of industrial and Engineering Chemistry, 27(5), 527-531. 10.14478/ace.2016.1078

Kasza, P., Dziadkiewicz, M., and Czupski, M., 2006. From laboratory research to successful practice: A case study of carbonate formation emulsified acid treatments, Proc. of the SPE International Symposium and Exhibition on Formation Damage Control, SPE, Lafayette, Louisiana, USA, p.1-7. 10.2118/98261-MS

Korea Energy Economics Institute, 2020.03.25., https://gscal texmediahub.com/energy/column-insight-of-future-petro-industry_202003#

Madyanova, M., Hezmela, R., Artola, P., Guimaraes, C.R., and Iriyanto, B., 2012. Effective matrix stimulation of high-temperature carbonate formations in south Sumatra through the combination of emulsified and viscoelastic self-diverting acids, Proc. of the SPE International Symposium and Exhibition on Formation Damage Control, SPE, Lafayette, Louisiana, USA, p.1-13. 10.2118/151070-MS

Nasr-El-Din, H.A., Solares, J.R., Al-Mutairi, S.H., and Mahoney, M.D., 2001. Field application of emulsified acid-based system to stimulate deep, sour gas reservoirs in Saudi Arabia, Proc. of the SPE Annual Technical Conference and Exhibition, SPE, New Orleans, Louisiana, USA, p.1-16. 10.2118/71693-MS

Roque, L., Fernandez, M., Benito, J.M., and Escudero, I., 2020. Stability and characterization studies of SPAN 80 niosomes modified with CTAB in the presence of NaCl, Journal of Colloids and Surfaces A, 601, 1-13. 10.1016/j.colsurfa.2020.124999

Sarma, D.K., Rao, Y.R.L., Mandal, B., and Bhargava, P.K., 2012. Application of self-diverting acid system for stimulation of multilayered wells in carbonate reservoir : A case study, Proc. of the SPE Oil and Gas India Conference and Exhibition, SPE, Mumbai, India, p.1-10. 10.2118/154554-MS

Sayed. M.A.I. and Nasr-El-Din. H.A., 2013. Acid treatments in high temperature dolomitic carbonate reservoirs using emulsified acids: A coreflood study, Proc. of the SPE Production and Operations Symposium, SPE, Oklahoma, USA, p.1-13. 10.2118/164487-MS

Sayed, M.A., Nasr-El-Din, H.A., and Nasrabadi, H., 2013. Reaction of emulsified acids with dolomite, Journal of Canadian Petroleum Technology, 52, p.164-175. 10.2118/151815-PA

Schlumberger, 2020.10.08., http://www.slb.com/services/ technical_challenges/carbonates.aspx#

Setiati, R., Siregar, S., Marhaendrajana, T., and Wahyningrum, D., 2018. Challenge sodium lignosulfonate surfactants synthesized from bagasse as an injection fluid based on hydrophil liphophilic balance, IOP Conference Series: Materials Science and Engineering, Volume 434, AASEC 2018, Bandung, Indonesia. 10.1088/1757-899X/434/1/012083

Sidaoui, Z. and Sultan, A.S., 2016. Formulating a stable emulsified acid at high temperatures : Stability and rheology study, Proc. of the International Petroleum Technology Conference, IPTC, Bangkok, Thailand, p.1-17. 10.2523/19012-MS26254429

Sidaoui, Z., Aly, M.T., Al-Murisi, M.A., and Qiu, X., 2018. Achieving higher retardation of emulsified acid by additive optimization, Proc. of the SPE Kingdom of Saudi Arabia Annual Technical Symposium and Exhibition, SPE, Dammam, Saudi Arabia, p.1-13. 10.2118/192346-MS

Sokhanvarian, K., Stanciu, C., Fernandez, J.M., Ibrahim, A., and Nasr-El-Din, H.A., 2019. Novel non-aromatic non-ionic surfactants to target deep carbonate stimulation, Proc. of the SPE International Conference on Oilfield Chemistry, SPE, Galveston, Texas, UAS, p.1-16. 10.2118/193596-MS

Song. C., Yoo. H., and Lee. J., 2021. Investigation on the technical characteristics and field cases of matrix acidizing treatment using emulsified acid in carbonate reservoirs, Journal of the Korean Society of Mineral and Energy Resources Engineers, 58(2), p.130-142. 10.32390/ksmer.2021.58.2.130

Wang, F., Yang, H., Jiang, H., Kang, X., Hou, X., Wang, T., Zhou, B., Sarsenbekuly, B., and Kang, W., 2020. Formation mechanism and location distribution of blockage during polymer flooding, Journal of Petroleum Science and Engineering, 194, p.1-10. 10.1016/j.petrol.2020.107503

Xiong, C., Zhou, F., Liu, Y,. Yang, X., Liu, X., Shi, Y., Tan, Y., Zhang, F., Ji, X., Qin, S., Huang, S., and Wang, X., 2010. Application and study of acid technique using novel selective emulsified acid system, Proc. of the International Oil and Gas Conference and Exhibition, SPE, Beijing, China, p.1-6. 10.2118/131216-MS

Yousufi, M.M., Elhaj, M.E.M., Moniruzzaman, M., Ayoub, M.A., Nazri, A.B.M., Husin, H.B., and Saaid, I.M., 2018. Synthesis and evaluation of jatropha oil-based emulsified acids for matrix acidizing of carbonate rocks, Journal of Petroleum Exploration and Production Technology, 9, p.1119-1133. 10.1007/s13202-018-0530-8

Yoo, H. and Lee, J., 2018. Investigation on the technical characteristics and field cases of matrix acidizing treatment in carbonate reservoirs, Journal of the Korean Society of Mineral and Energy Resources Engineers, 55(2), p.147-158. 10.12972/ksmer.2018.55.2.147

Yoo, H., Kim, Y., Lee, W., and Lee, J., 2018. An experimental study on acid-rock reaction kinetics using dolomite in carbonate acidizing, Journal of Petroleum Science and Engineering, 168, p.478-494. 10.1016/j.petrol.2018.05.041

Yoo, H. and Lee, J., 2019. An experimental study on the optimum injection rate for matrix acidizing in carbonate reservoirs, Journal of the Korean Society of Mineral and Energy Resources Engineers, 56(3), p.227-238. 10.32390/ksmer.2019.56.3.227

Yoo, H., Park, J., Lee, Y., and Lee, J., 2019. An experimental investigation into the effect of pore size distribution on the acid-rock reaction in carbonate acidizing, Journal of Petroleum Science and Engineering, 180, p.504-517. 10.1016/j.petrol.2019.05.061

Information

Publisher :The Korean Society of Mineral and Energy Resources Engineers
Publisher(Ko) :한국자원공학회
Journal Title :Journal of the Korean Society of Mineral and Energy Resources Engineers
Journal Title(Ko) :한국자원공학회지
Volume : 58
No :6
Pages :568-579
Received Date :2021. 12. 07
Revised Date :2021. 12. 23
Accepted Date : 2021. 12. 27
DOI :https://doi.org/10.32390/ksmer.2021.58.6.568

Journal of the Korean Society of Mineral and Energy Resources Engineers ISSN:2288-0291(Print) 2288-2790(Online) 한국자원공학회지

All Issue